Recently, there have been reports of price crashes and distress sales in case of farm produce, such as tomatoes, mangoes, and garlic. In some cases, farmers have dumped their produce on roads. Produce such as fruits and vegetables are perishable and therefore have a short shelf life. Further, due to inadequate storage facilities and poor food processing infrastructure farmers have limited options but to sell the produce at prevailing market prices. This can lead to distress sales or roadside discards (in some cases to avoid additional cost of transportation).
Food processing allows raw food to be stored, marketed, or preserved for consumption later. For instance, raw agricultural produce such as fruits may be processed into juices, jams, and pickles. Activities such as waxing (for preservation), packaging, labelling, or ripening of produce also form part of the food processing industry.
Between 2001-02 and 2016-17, production of food grains grew annually at 1.7% on average. Production of horticulture crops surpassed food grains with an average growth rate of 4.8%. While production has been increasing over the years, surplus produce tends to go waste at various stages such as procurement, storage, and processing due to lack of infrastructure such as cold storages and food processing units.
Source: Horticulture Statistics at a Glance 2017, Union Budget 2018-19; PRS.
Losses high among perishables such as fruits and vegetables
Crop losses ranged between 7-16% among fruits and around 5% among cereals in 2015. The highest losses were witnessed in case of guava, followed by mango, which are perishable fruits. Perishables such as fruits and vegetables are more prone to losses as compared to cereals. Such crop losses can occur during operations such as harvesting, thrashing, grading, drying, packaging, transportation, and storage depending upon the commodity.
It was estimated that the annual value of harvest and post-harvest losses of major agricultural products at the national level was Rs 92,651 crore in 2015. The Standing Committee on Agriculture (2017) stated that such wastage can be reduced with adequate food processing facilities.
Sources: Annual Report 2016-17, Ministry of Food Processing Industries; PRS.
Inadequate food processing infrastructure
As previously discussed, perishables such as fruits and vegetables are more prone to damages as compared to cereals. Due to inadequate processing facilities in close proximity, farmers may be unable to hold their produce for a long time. Hence, they may be forced to sell their produce soon after harvest, irrespective of the prevailing market situations. Expert committees have recommended that agri-logistics such as cold chain infrastructure and market linkages should be strengthened.
Cold chain infrastructure: Cold chain infrastructure includes processing units, cold storages, and refrigerated vans. As of 2014, out of a required cold storage capacity of 35 million metric tonnes (MT), almost 90% (31.8 million MT) of the capacity was available (see Table 1). However, cold storage needs to be coupled with logistical support to facilitate smooth transfer of harvested value from farms to distant locations. This includes: (i) pack-houses for packaging and preparing fresh produce for long distance transport, (ii) refrigerated transport such as reefer vehicles, and (iii) ripening chambers to ripen raw produce before marketing. For instance, bananas which are harvested raw may be ripened in these chambers before being marketed.
While there are sufficient cold storages, there are wide gaps in the availability of other associated infrastructure. This implies that even though almost 90% (32 million tonnes) of cold storage capacity is available, only 15% of the required refrigerated transport exists. Further, the shortfall in the availability of infrastructure necessary for safe handling of farm produce, like pack-houses and ripening chambers, is over 90%.
Table 1: Gaps in cold chain infrastructure (2014)
| Facility | Required | Available | Gap | % gap |
| Cold storage (in million MT) |
35.1 |
31.8 | 3.2 |
9.3% |
| Pack-houses |
70,080 |
249 | 69,831 |
99.6% |
| Reefer vehicles |
61,826 |
9,000 | 52,826 |
85.4% |
| Ripening chambers |
9,131 |
812 | 8,319 |
91.1% |
To minimise post-harvest losses, the Standing Committee (2017) recommended that a country-wide integrated cold chain infrastructure network at block and district levels should be created. It further recommended that a Cold Chain Coordination and Monitoring Committee should be constituted at the district-level. The Standing Committee also recommended that farmers need to be trained in value addition activities such as sorting, grading, and pre-cooling harvested produce through facilities such as freezers and ripening chambers.
Between 2008 and 2017, 238 cold chain projects were sanctioned under the Scheme for Integrated Cold Chain and Value Addition Infrastructure. Grants worth Rs 1,775 crore were approved for these projects. Of this amount, Rs 964 crore (54%) has been released as of January 2018. Consequently, out of the total projects sanctioned, 114 (48%) are completed. The remaining 124 projects are currently under implementation.
Transport Facilities: Currently, majority of food grains and certain quantities of tea, potato, and onion are transported through railways. The Committee on Doubling Farmers Income had recommended that railways needs to upgrade its logistics to facilitate the transport of fresh produce directly to export hubs. This includes creation of adjoining facilities for loading and unloading, and distribution to road transport.
Mega Food Parks: The Mega Food Parks scheme was launched in 2008. It seeks to facilitate setting up of food processing units. These units are to be located at a central processing centre with infrastructure required for processing, packaging, quality control labs, and trade facilitation centres.
As of March 2018, out of the 42 projects approved, 10 were operational. The Standing Committee on Agriculture noted certain reasons for delay in implementation of projects under the scheme. These include: (i) difficulty in getting loans from banks for the project, (ii) delay in obtaining clearances from the state governments and agencies for roads, power, and water at the project site, (iii) lack of special incentives for setting up food processing units in Mega Food Parks, and (iv) unwillingness of the co-promoters in contributing their share of equity.
Further, the Standing Committee stated that as the scheme requires a minimum area of 50 acres, it does not to promote smaller or individual food processing and preservation units. It recommended that smaller agro-processing clusters near production areas must be promoted. The Committee on Doubling Farmers Income recommended establishment of processing and value addition units at strategic places. This includes rural or production areas for pulses, millets, fruits, vegetables, dairy, fisheries, and poultry in public private-partnership mode.
Recently, the Kelkar Committee published a roadmap for fiscal consolidation. The report stresses the need and urgency to address India’s fiscal deficit. A high fiscal deficit – the excess of government expenditure over receipts – can be problematic for many reasons. The fiscal deficit is financed by government borrowing; increased borrowing can crowd out funds available for private investment. High government spending can also lead to a rise in price levels. A full PRS summary of the report can be found here. Recent fiscal trends Last year (2011-12), the central government posted a fiscal deficit of 5.8% (of GDP), significantly higher than the targeted 4.6%. This is in stark contrast to five years ago in 2007-08, when after embarking on a path of fiscal consolidation the government’s fiscal deficit had shrunk to a 30 year low of 2.5%. In 2008-09, a combination of the Sixth Pay Commission, farmers’ debt waiver and a crisis-driven stimulus led to the deficit rising to 6% and it has not returned to those levels since. As of August this year, government accounts reveal a fiscal deficit of Rs 3,37,538 crore which is 65.7% of the targeted deficit with seven months to go in the fiscal year. With growth slowing this year, the committee expects tax receipts to fall short of expectations significantly and expenditure to overshoot budget estimates, leaving the economy on the edge of a “fiscal precipice”.
Figure 1 (source: RBI)
Committee recommendations - expenditure To tackle the deficit on the expenditure side, the committee wants to ease the subsidy burden. Subsidy expenditure, as a percentage of GDP, has crept up in the last two years (see Figure 2) and the committee expects it to reach 2.6% of GDP in 2012-13. In response, the committee calls for an immediate increase in the price of diesel, kerosene and LPG. The committee also recommends phasing out the subsidy on diesel and LPG by 2014-15. Initial reports suggest that the government may not support this phasing out of subsidies.
Figure 2 (source: RBI, Union Budget documents, PRS)
For the fertiliser subsidy, the committee recommends implementing the Department of Fertilisers proposal of a 10% price increase on urea. Last week , the government raised the price of urea by Rs 50 per tonne (a 0.9% increase). Finally, the committee explains the rising food subsidy expenditure as a mismatch between the issue price and the minimum support price and wants this to be addressed. Committee recommendations - receipts Rising subsidies have not been matched by a significant increase in receipts through taxation: gross tax revenue as a percentage of GDP has remained around 10% of GDP (see Figure 3). The committee seeks to improve collections in both direct and indirect taxes via better tax administration. Over the last decade, income from direct taxes – the tax on income – has emerged as the biggest contributor to the Indian exchequer. The committee feels that the pending Direct Tax Code Bill would result in significant losses and should be reviewed. To boost income from indirect taxes – the tax on goods and services – the committee wants the proposed Goods and Service Tax regime to be implemented as soon as possible.
Figure 3 (source: RBI)
Increasing disinvestment, the process of selling government stake in public enterprises, is another proposal to boost receipts. India has failed to meet the disinvestment estimate set out in the Budget in the last two years (Figure 4). The committee believes introducing new channels [1. The committee suggests introducing a ‘call option model’. This is a mechanism allowing the government to offer for sale multiple securities over a period of time till disinvestment targets are achieved. Investors would have the option to purchase securities at the cost of a premium. They also propose introducing ‘exchange traded funds’ which would comprise all listed securities of Central Public Sector Enterprises and would provide investors with the benefits of diversification, low cost access and flexibility.] for disinvestment would ensure that disinvestment receipts would meet this year’s target of Rs 30,000 crore.
Figure 4 (source: Union Budget documents, PRS)
Taken together, these policy changes, the committee believe would significantly improve India’s fiscal health and boost growth. Their final projections for 2012-13, in both a reform and no reform scenario, and the medium term (2013-14 and 2014-15) are presented in the table below: [table id=2 /]
