Recently, there have been reports of price crashes and distress sales in case of farm produce, such as tomatoes, mangoes, and garlic. In some cases, farmers have dumped their produce on roads. Produce such as fruits and vegetables are perishable and therefore have a short shelf life. Further, due to inadequate storage facilities and poor food processing infrastructure farmers have limited options but to sell the produce at prevailing market prices. This can lead to distress sales or roadside discards (in some cases to avoid additional cost of transportation).
Food processing allows raw food to be stored, marketed, or preserved for consumption later. For instance, raw agricultural produce such as fruits may be processed into juices, jams, and pickles. Activities such as waxing (for preservation), packaging, labelling, or ripening of produce also form part of the food processing industry.
Between 2001-02 and 2016-17, production of food grains grew annually at 1.7% on average. Production of horticulture crops surpassed food grains with an average growth rate of 4.8%. While production has been increasing over the years, surplus produce tends to go waste at various stages such as procurement, storage, and processing due to lack of infrastructure such as cold storages and food processing units.
Source: Horticulture Statistics at a Glance 2017, Union Budget 2018-19; PRS.
Losses high among perishables such as fruits and vegetables
Crop losses ranged between 7-16% among fruits and around 5% among cereals in 2015. The highest losses were witnessed in case of guava, followed by mango, which are perishable fruits. Perishables such as fruits and vegetables are more prone to losses as compared to cereals. Such crop losses can occur during operations such as harvesting, thrashing, grading, drying, packaging, transportation, and storage depending upon the commodity.
It was estimated that the annual value of harvest and post-harvest losses of major agricultural products at the national level was Rs 92,651 crore in 2015. The Standing Committee on Agriculture (2017) stated that such wastage can be reduced with adequate food processing facilities.
Sources: Annual Report 2016-17, Ministry of Food Processing Industries; PRS.
Inadequate food processing infrastructure
As previously discussed, perishables such as fruits and vegetables are more prone to damages as compared to cereals. Due to inadequate processing facilities in close proximity, farmers may be unable to hold their produce for a long time. Hence, they may be forced to sell their produce soon after harvest, irrespective of the prevailing market situations. Expert committees have recommended that agri-logistics such as cold chain infrastructure and market linkages should be strengthened.
Cold chain infrastructure: Cold chain infrastructure includes processing units, cold storages, and refrigerated vans. As of 2014, out of a required cold storage capacity of 35 million metric tonnes (MT), almost 90% (31.8 million MT) of the capacity was available (see Table 1). However, cold storage needs to be coupled with logistical support to facilitate smooth transfer of harvested value from farms to distant locations. This includes: (i) pack-houses for packaging and preparing fresh produce for long distance transport, (ii) refrigerated transport such as reefer vehicles, and (iii) ripening chambers to ripen raw produce before marketing. For instance, bananas which are harvested raw may be ripened in these chambers before being marketed.
While there are sufficient cold storages, there are wide gaps in the availability of other associated infrastructure. This implies that even though almost 90% (32 million tonnes) of cold storage capacity is available, only 15% of the required refrigerated transport exists. Further, the shortfall in the availability of infrastructure necessary for safe handling of farm produce, like pack-houses and ripening chambers, is over 90%.
Table 1: Gaps in cold chain infrastructure (2014)
| Facility | Required | Available | Gap | % gap |
| Cold storage (in million MT) |
35.1 |
31.8 | 3.2 |
9.3% |
| Pack-houses |
70,080 |
249 | 69,831 |
99.6% |
| Reefer vehicles |
61,826 |
9,000 | 52,826 |
85.4% |
| Ripening chambers |
9,131 |
812 | 8,319 |
91.1% |
To minimise post-harvest losses, the Standing Committee (2017) recommended that a country-wide integrated cold chain infrastructure network at block and district levels should be created. It further recommended that a Cold Chain Coordination and Monitoring Committee should be constituted at the district-level. The Standing Committee also recommended that farmers need to be trained in value addition activities such as sorting, grading, and pre-cooling harvested produce through facilities such as freezers and ripening chambers.
Between 2008 and 2017, 238 cold chain projects were sanctioned under the Scheme for Integrated Cold Chain and Value Addition Infrastructure. Grants worth Rs 1,775 crore were approved for these projects. Of this amount, Rs 964 crore (54%) has been released as of January 2018. Consequently, out of the total projects sanctioned, 114 (48%) are completed. The remaining 124 projects are currently under implementation.
Transport Facilities: Currently, majority of food grains and certain quantities of tea, potato, and onion are transported through railways. The Committee on Doubling Farmers Income had recommended that railways needs to upgrade its logistics to facilitate the transport of fresh produce directly to export hubs. This includes creation of adjoining facilities for loading and unloading, and distribution to road transport.
Mega Food Parks: The Mega Food Parks scheme was launched in 2008. It seeks to facilitate setting up of food processing units. These units are to be located at a central processing centre with infrastructure required for processing, packaging, quality control labs, and trade facilitation centres.
As of March 2018, out of the 42 projects approved, 10 were operational. The Standing Committee on Agriculture noted certain reasons for delay in implementation of projects under the scheme. These include: (i) difficulty in getting loans from banks for the project, (ii) delay in obtaining clearances from the state governments and agencies for roads, power, and water at the project site, (iii) lack of special incentives for setting up food processing units in Mega Food Parks, and (iv) unwillingness of the co-promoters in contributing their share of equity.
Further, the Standing Committee stated that as the scheme requires a minimum area of 50 acres, it does not to promote smaller or individual food processing and preservation units. It recommended that smaller agro-processing clusters near production areas must be promoted. The Committee on Doubling Farmers Income recommended establishment of processing and value addition units at strategic places. This includes rural or production areas for pulses, millets, fruits, vegetables, dairy, fisheries, and poultry in public private-partnership mode.
Most legislative assemblies make Parliament look like a paragon of virtue A COUPLE of days ago, an MLA from Orissa made news for climbing on to the speaker's table in the assembly. Not so long ago, television screens beamed images of Karnataka MLAs snacking and sleeping all night in the assembly. But these are only indicative of the incidents of the raucous behaviour of several MLAs in the recent past across the country. And the poor behaviour of some MLAs is only one aspect of the pitiable state of several of our state legislatures. The other aspect of our state legislatures that goes largely unnoticed is how poorly the secretariats of legislatures are equipped and how several systems that are seen as essential in Parliament are nonexistent in states. Even to know the complete picture of how our legislatures function, you need data. And several state assemblies are notoriously poor at putting out data on the functioning of the institution or the MLAs. After one gets used to the quality of Parliament websites and the regularity of their updates, it would be shocking to see that there are some state legislatures that do not even have functional websites. It has been observed that some state legislatures are lagging behind by a couple of years in compiling the "resume of work" which summarises the work done in a session of the legislature. So the first bottleneck in several instances is the inability to access data of the assembly. From the data we have managed to access, it is obvious that state assemblies meet for very few days a year. A case in point is the Punjab assembly which has met for an average of 19 days per year for a 10-year period between 1997 and 2007. Delhi was only marginally better averaging 21 days per year during the same period. Kerala has averaged some 50 days a year for several years now. Some states like Karnataka have legislated that they should meet for at least 60 days a year, but since passing that legislation in 2005, they have not managed to do so for even one year. I am not even accounting for the time lost due to disruptions. Bills are passed with little or no discussion in many state legislatures. While in Parliament, referring bills to the standing committees is the norm, most state legislatures do not have standing committees. The only examination of a bill, if any, happens on the floor of the House. And if data from the Delhi assembly is anything to go by, the average debate on a bill before is passed is a little over half hour. There are any number of instances where bills are introduced and passed in state assemblies on the same day -so there is not even a pretence of the need for MLAs to read, understand and deliberate on the provisions of legislation they are supposedly passing. MLAs are often far more narrowly constituency-focused than MPs are. On average, MLAs have lower education levels than members of Parliament. There is no formal definition of a role of an MLA, and they mostly have no exposure to ideas such as the separation of powers between the executive and the legislature. In one particularly revealing conversation with an MLA, he said, "At the time of elections, each of the contestants represents his party. But after the elections, the chiefministerbecomestheleader of all MLAs in the House. If an MLAneedssomeadditionalprojects/ favours for his constituency he needs to be in the good books of the chief minister and his cabinet ministers. So where is the question of taking on the chief minister on the floor of the House on any issue?" There are many aspects of state legislatures that point to a steady and visible decline of these important institutions. But beyond the frequent highlighting of theatrics by some MLAs, there is almost no public discourse on this issue. It is necessary to ensure that the legislatures run smoothly, and the speaker, as first among equals, has the biggest responsibility to ensure this. If there are rules and everyone knows that those rules will never be used to enforce discipline, then the rules will be broken, and repeatedly so. This practice needs to be urgently reviewed. The larger question is whether our legislatures are the highest deliberating and policymaking bodies or whether they are being reduced to platforms for political theatrics. Policy can almost never be devoid of politics and public posturing. But if this means poor deliberation of critical policy issues and the woefully inadequate functioning of our legislatures, then we may need to come up with creative ways in which this problem can be addressed. This article appeared in the Indian Express on December 20, 2010.
