Applications for LAMP Fellowship 2025-26 are now open. Apply here. The last date for submitting applications is December 21, 2024
Recently, there have been reports of price crashes and distress sales in case of farm produce, such as tomatoes, mangoes, and garlic. In some cases, farmers have dumped their produce on roads. Produce such as fruits and vegetables are perishable and therefore have a short shelf life. Further, due to inadequate storage facilities and poor food processing infrastructure farmers have limited options but to sell the produce at prevailing market prices. This can lead to distress sales or roadside discards (in some cases to avoid additional cost of transportation).
Food processing allows raw food to be stored, marketed, or preserved for consumption later. For instance, raw agricultural produce such as fruits may be processed into juices, jams, and pickles. Activities such as waxing (for preservation), packaging, labelling, or ripening of produce also form part of the food processing industry.
Between 2001-02 and 2016-17, production of food grains grew annually at 1.7% on average. Production of horticulture crops surpassed food grains with an average growth rate of 4.8%. While production has been increasing over the years, surplus produce tends to go waste at various stages such as procurement, storage, and processing due to lack of infrastructure such as cold storages and food processing units.
Source: Horticulture Statistics at a Glance 2017, Union Budget 2018-19; PRS.
Losses high among perishables such as fruits and vegetables
Crop losses ranged between 7-16% among fruits and around 5% among cereals in 2015. The highest losses were witnessed in case of guava, followed by mango, which are perishable fruits. Perishables such as fruits and vegetables are more prone to losses as compared to cereals. Such crop losses can occur during operations such as harvesting, thrashing, grading, drying, packaging, transportation, and storage depending upon the commodity.
It was estimated that the annual value of harvest and post-harvest losses of major agricultural products at the national level was Rs 92,651 crore in 2015. The Standing Committee on Agriculture (2017) stated that such wastage can be reduced with adequate food processing facilities.
Sources: Annual Report 2016-17, Ministry of Food Processing Industries; PRS.
Inadequate food processing infrastructure
As previously discussed, perishables such as fruits and vegetables are more prone to damages as compared to cereals. Due to inadequate processing facilities in close proximity, farmers may be unable to hold their produce for a long time. Hence, they may be forced to sell their produce soon after harvest, irrespective of the prevailing market situations. Expert committees have recommended that agri-logistics such as cold chain infrastructure and market linkages should be strengthened.
Cold chain infrastructure: Cold chain infrastructure includes processing units, cold storages, and refrigerated vans. As of 2014, out of a required cold storage capacity of 35 million metric tonnes (MT), almost 90% (31.8 million MT) of the capacity was available (see Table 1). However, cold storage needs to be coupled with logistical support to facilitate smooth transfer of harvested value from farms to distant locations. This includes: (i) pack-houses for packaging and preparing fresh produce for long distance transport, (ii) refrigerated transport such as reefer vehicles, and (iii) ripening chambers to ripen raw produce before marketing. For instance, bananas which are harvested raw may be ripened in these chambers before being marketed.
While there are sufficient cold storages, there are wide gaps in the availability of other associated infrastructure. This implies that even though almost 90% (32 million tonnes) of cold storage capacity is available, only 15% of the required refrigerated transport exists. Further, the shortfall in the availability of infrastructure necessary for safe handling of farm produce, like pack-houses and ripening chambers, is over 90%.
Table 1: Gaps in cold chain infrastructure (2014)
| Facility | Required | Available | Gap | % gap |
| Cold storage (in million MT) |
35.1 |
31.8 | 3.2 |
9.3% |
| Pack-houses |
70,080 |
249 | 69,831 |
99.6% |
| Reefer vehicles |
61,826 |
9,000 | 52,826 |
85.4% |
| Ripening chambers |
9,131 |
812 | 8,319 |
91.1% |
To minimise post-harvest losses, the Standing Committee (2017) recommended that a country-wide integrated cold chain infrastructure network at block and district levels should be created. It further recommended that a Cold Chain Coordination and Monitoring Committee should be constituted at the district-level. The Standing Committee also recommended that farmers need to be trained in value addition activities such as sorting, grading, and pre-cooling harvested produce through facilities such as freezers and ripening chambers.
Between 2008 and 2017, 238 cold chain projects were sanctioned under the Scheme for Integrated Cold Chain and Value Addition Infrastructure. Grants worth Rs 1,775 crore were approved for these projects. Of this amount, Rs 964 crore (54%) has been released as of January 2018. Consequently, out of the total projects sanctioned, 114 (48%) are completed. The remaining 124 projects are currently under implementation.
Transport Facilities: Currently, majority of food grains and certain quantities of tea, potato, and onion are transported through railways. The Committee on Doubling Farmers Income had recommended that railways needs to upgrade its logistics to facilitate the transport of fresh produce directly to export hubs. This includes creation of adjoining facilities for loading and unloading, and distribution to road transport.
Mega Food Parks: The Mega Food Parks scheme was launched in 2008. It seeks to facilitate setting up of food processing units. These units are to be located at a central processing centre with infrastructure required for processing, packaging, quality control labs, and trade facilitation centres.
As of March 2018, out of the 42 projects approved, 10 were operational. The Standing Committee on Agriculture noted certain reasons for delay in implementation of projects under the scheme. These include: (i) difficulty in getting loans from banks for the project, (ii) delay in obtaining clearances from the state governments and agencies for roads, power, and water at the project site, (iii) lack of special incentives for setting up food processing units in Mega Food Parks, and (iv) unwillingness of the co-promoters in contributing their share of equity.
Further, the Standing Committee stated that as the scheme requires a minimum area of 50 acres, it does not to promote smaller or individual food processing and preservation units. It recommended that smaller agro-processing clusters near production areas must be promoted. The Committee on Doubling Farmers Income recommended establishment of processing and value addition units at strategic places. This includes rural or production areas for pulses, millets, fruits, vegetables, dairy, fisheries, and poultry in public private-partnership mode.
Last week, the Power Finance Corporation reported that state-owned power distribution companies across the country made financial losses amounting to Rs 68,832 crore in 2022-23. This is four times higher than the losses witnessed in 2021-22, and roughly equivalent to the annual budget of a state like Uttarakhand. This blog examines some of the causes and implications of such losses.
Overview of financial losses
For several years now, electricity distribution companies (discoms), which are mostly state-owned, have witnessed steep financial losses. Between 2017-18 and 2022-23, losses accumulated to over three lakh crore rupees. In 2021-22, discom witnessed substantial reduction in their losses, primarily because states released 1.54 lakh rupees in subsidies to clear pending dues. State governments provide discoms with subsidies, so that domestic and agricultural consumers receive affordable power. These payments are typically delayed which creates cash flow constraints, and leads to an accumulation of debt. In addition, costs incurred by discoms in 2021-22 remained unchanged.
Note: Data from 2020-21 onwards does not include Odisha, and Dadra & Nagar Haveli and Daman and Diu since their distribution function was privatised in 2020-21. Data for Ladakh is available from 2021-22 onwards. Data for Jammu and Kashmir is not available. The Delhi Municipal Council Distribution Utility has been included from 2020-21 onwards.
Sources: Power Finance Corporation reports for various years; PRS.
As of 2022-23, losses have increased again to reach Rs 68,832 crore. This increase has been driven by rising costs. At a per unit level, the cost of supplying one kilowatt of electricity rose from 7.6 rupees in 2021-22, to 8.6 rupees in 2022-23 (See Table 1).
Table 1: Financial details of state-owned power distribution companies
|
Details |
2019-20 |
2020-21 |
2021-22 |
2022-23 |
|
Average cost of supplying power (ACS) |
7.4 |
7.7 |
7.6 |
8.6 |
|
Average revenue realised (ARR) |
6.8 |
7.1 |
7.3 |
7.8 |
|
Per unit loss (ACS-ARR) |
0.6 |
0.6 |
0.3 |
0.7 |
|
Total losses (in Rs crore) |
-60,231 |
-76,899 |
-16,579 |
-68,832 |
Note: Data from 2020-21 onwards does not include Odisha, and Dadra & Nagar Haveli and Daman and Diu since their distribution function was privatised in 2020-21. Data for Ladakh is available from 2021-22 onwards. Data for Jammu and Kashmir is not available. The Delhi Municipal Council Distribution Utility has been included from 2020-21 onwards.
Sources: Power Finance Corporation reports for various years; PRS.
Purchase of electricity from generation companies (gencos) forms about 70% of a discom’s total costs, and coal is the primary source for generating electricity. The following chain of events took place in 2022-23: (i) consumer demand for electricity rose by 10% over the previous year, as compared to a 6% year-on-year increase in the past 10 years, (ii) coal had to be imported to meet the increased demand, and (iii) global coal prices were elevated.
Coal imported at elevated prices to keep up with rising electricity demand
In 2022-23, demand for electricity increased by 10% over 2021-22. Between 2008-09 and 2018-19, demand increased at an annual growth rate (CAGR) of 6%. Electricity demand grew as the economy grew (at 7%), and largely came from domestic and agricultural consumers. These consumer categories account for 54% of the total electricity sales, and their demand rose by 7%.
Sources: Central Electricity Regulatory Commission; PRS.
Electricity cannot be stored at scale, which means that generation must be scheduled depending on anticipated demand. The Central Electricity Authority anticipates annual demand for each year. It estimated that demand in 2022-23 would be at 1,505 billion units. However, the actual demand was higher than anticipated in the first few months of 2022-23 (See Figure 3).
To meet this demand, electricity generation had to be ramped up. Coal stocks had already depleted from 29 million tonnes in June 2021 to eight million tonnes in September 2021, on account of high demand in 2021-22. To ensure uninterrupted supply of power, the Ministry of Power directed gencos to import coal. The Ministry noted that without imports, widespread power cuts and blackouts would have occurred.
Sources: Load Generation Balance Report 2022 and 2023, Central Electricity Authority; PRS.
Coal imports rose by about 27 million tonnes in 2022-23. While this constituted only 5% of the overall coal used in the sector, the price at which it was imported significantly impacted the sector. In 2021-22, India imported coal at an average price of Rs 8,300 per tonne. This rose to Rs 12,500 per tonne in 2022-23, a 51% increase. Coal was primarily imported from Indonesia, and prices shot up due to the Russia-Ukraine war, and demand surge by countries like India and China.
Sources: Ministry of Power; Ministry of Statistics and Programme Implementation; PRS.
Coal import situation going forward
In January 2023, the Ministry of Power advised gencos to import 6% of the required coal, to ensure sufficient stock until September 2023. It noted that due to floods and variable rainfall in various parts of the country, hydro generation capacity reduced by about 14%. This put additional burden on coal based thermal generation in 2023-24. Following this, in October 2023, the Ministry directed all gencos to continue using at least 6% imported coal until March 2024.
Sources: Ministry of Coal; PRS.
Structural issues in the power sector and its impact on state finances
Discoms witness persistent financial losses due to certain structural issues. Their costs are typically high because of old contracts with generation companies (gencos). Power purchase costs in these contracts do not account for production efficiencies over the years, and costs remain unchanged. Tariffs are only revised every few years, to ensure that consumers are protected from supply chain shocks. As a result, costs are carried forward for a few years. In addition, discoms sell electricity to certain consumers such as agricultural and residential consumers, below cost. This is supposed to primarily be recovered through subsidy grants provided by state governments. However, states often delay subsidy payments leading to cash flow issues, and accumulation of debt. In addition, tariff recovery from the power sold is not optimal.
Losses reported in the generation sector have also increased. In 2022-23, state-owned gencos reported losses worth Rs 7,175 crore, as compared to the Rs 4,245 crore in 2021-22. Rajasthan accounted for 87% of these, at Rs 6,278 crore. Note that under the Late Payment Surcharge Rules, 2022, discoms are required to make upfront payments to gencos.
Risk to state finances
Persistent financial losses, high debt and guarantees extended by states continue to pose a risk to state finances. These are contingent liabilities for state governments, i.e., in the event a discom is unable to repay its debt, the state would have to take it over.
Several such schemes have been introduced in the past to bail discoms out (See Table 2). As of 2022-23, discoms have an outstanding debt worth Rs 6.61 lakh crore, 2.4% of the national GDP. Debt is significantly high in states such as Tamil Nadu (6% of GSDP), Rajasthan (6% of GSDP), and Uttar Pradesh (3% of GSDP). Previous Finance Commissions have recognised that strengthening discom finances is key in minimising the risk to state finances.
Table 2: Key government schemes for the turnaround of the distribution sector over the years
|
Year |
Scheme |
Details |
|
2002 |
Bailout Package |
States take over the debt of state electricity boards worth Rs 35,000 crore, 50% waiver of interest payable by state electricity boards to central PSUs |
|
2012 |
Financial Restructuring Package |
States take over 50% of the outstanding short-term liabilities worth Rs 56,908 crore |
|
2015 |
Ujwal Discom Assurance Yojana (UDAY) |
States take over 75% of the debt of discoms worth Rs 2.3 lakh crore and also provide grants for any future losses |
|
2020 |
Liquidity Infusion Scheme |
Discoms get loans worth Rs 1.35 lakh crore from Power Finance Corporation and REC Limited to settle outstanding dues of generators, state governments provide guarantee |
|
2022 |
Revamped Distribution Sector Scheme |
Central government to provide result-linked financial assistance worth Rs 97,631 crore for strengthening of supply infrastructure |
Sources: NITI Aayog, Press Releases of the Ministry of Power; PRS.
For more details on the impact of discom finances on state finances, see here. For more details on structural issues in the power distribution sector, see here.
ANNEXURE
Table 3: Cost and revenue structure of discoms on energy sold basis (in Rs per kw)
|
Details |
2019-20 |
2020-21 |
2021-22 |
2022-23 |
|
Average cost of supplying power (ACS) |
7.4 |
7.7 |
7.6 |
8.6 |
|
of which |
||||
|
Cost of procuring power |
5.8 |
5.9 |
5.8 |
6.6 |
|
Average revenue realised (ARR) |
6.8 |
7.1 |
7.3 |
7.8 |
|
of which |
||||
|
Revenue from sale of power |
5.0 |
4.9 |
5.1 |
5.5 |
|
Tariff subsidy |
1.3 |
1.4 |
1.4 |
1.5 |
|
Regulatory income and revenue grant under UDAY |
0.3 |
0.1 |
0.0 |
0.2 |
|
Per unit loss |
0.6 |
0.6 |
0.3 |
0.7 |
|
Total financial losses |
-60,231 |
-76,899 |
-16,579 |
-68,832 |
Sources: Power Finance Corporation reports for various years; PRS.
Table 4: State-wise profit/loss of power distribution companies (in Rs crore)
|
State/UT |
2017-18 |
2018-19 |
2019-20 |
2020-21 |
2021-22 |
2022-23 |
|
Andaman and Nicobar Islands |
-605 |
-645 |
-678 |
-757 |
-86 |
-76 |
|
Andhra Pradesh |
-546 |
-16,831 |
1,103 |
-6,894 |
-2,595 |
1,211 |
|
Arunachal Pradesh |
-429 |
-420 |
NA |
NA |
NA |
NA |
|
Assam |
-259 |
311 |
1,141 |
-107 |
357 |
-800 |
|
Bihar |
-1,872 |
-1,845 |
-2,913 |
-2,966 |
-2,546 |
-10 |
|
Chandigarh |
321 |
131 |
59 |
79 |
-101 |
NA |
|
Chhattisgarh |
-739 |
-814 |
-571 |
-713 |
-807 |
-1,015 |
|
Dadra & Nagar Haveli and Daman & Diu |
312 |
-149 |
-125 |
NA |
NA |
NA |
|
Delhi |
NA |
NA |
NA |
98 |
57 |
-141 |
|
Goa |
26 |
-121 |
-276 |
78 |
117 |
69 |
|
Gujarat |
426 |
184 |
314 |
429 |
371 |
147 |
|
Haryana |
412 |
281 |
331 |
637 |
849 |
975 |
|
Himachal Pradesh |
-44 |
132 |
43 |
-153 |
-141 |
-1,340 |
|
Jharkhand |
-212 |
-730 |
-1,111 |
-2,556 |
-1,721 |
-3,545 |
|
Karnataka |
-2,439 |
-4,889 |
-2,501 |
-5,382 |
4,719 |
-2,414 |
|
Kerala |
-784 |
-135 |
-270 |
-483 |
98 |
-1,022 |
|
Ladakh |
NA |
NA |
NA |
NA |
-11 |
-57 |
|
Lakshadweep |
-98 |
-120 |
-115 |
-117 |
NA |
NA |
|
Madhya Pradesh |
-5,802 |
-9,713 |
-5,034 |
-9,884 |
-2,354 |
1,842 |
|
Maharashtra |
-3,927 |
2,549 |
-5,011 |
-7,129 |
-1,147 |
-19,846 |
|
Manipur |
-8 |
-42 |
-15 |
-15 |
-22 |
-146 |
|
Meghalaya |
-287 |
-202 |
-443 |
-101 |
-157 |
-193 |
|
Mizoram |
87 |
-260 |
-291 |
-115 |
-59 |
-158 |
|
Nagaland |
-62 |
-94 |
-477 |
-17 |
24 |
33 |
|
Puducherry |
5 |
-39 |
-306 |
-23 |
84 |
-131 |
|
Punjab |
-2,760 |
363 |
-975 |
49 |
1,680 |
-1,375 |
|
Rajasthan |
-11,314 |
-12,524 |
-12,277 |
-5,994 |
2,374 |
-2,024 |
|
Sikkim |
-29 |
-3 |
-179 |
-34 |
NA |
71 |
|
Tamil Nadu |
-12,541 |
-17,186 |
-16,528 |
-13,066 |
-9,130 |
-9,192 |
|
Telangana |
-6,697 |
-9,525 |
-6,966 |
-6,686 |
-831 |
-11,103 |
|
Tripura |
28 |
38 |
-104 |
-4 |
-127 |
-193 |
|
Uttar Pradesh |
-5,269 |
-5,902 |
-3,866 |
-10,660 |
-6,498 |
-15,512 |
|
Uttarakhand |
-229 |
-808 |
-323 |
-152 |
-21 |
-1,224 |
|
West Bengal |
-871 |
-1,171 |
-1,867 |
-4,261 |
1,045 |
-1,663 |
|
State Sector |
-56,206 |
-80,179 |
-60,231 |
-76,899 |
-16,579 |
-68,832 |
|
Dadra & Nagar Haveli and Daman & Diu |
NA |
NA |
NA |
242 |
148 |
104 |
|
Delhi |
109 |
657 |
-975 |
1,876 |
521 |
-76 |
|
Gujarat |
574 |
307 |
612 |
655 |
522 |
627 |
|
Odisha |
NA |
NA |
-842 |
-853 |
940 |
746 |
|
Maharashtra |
NA |
590 |
1,696 |
-375 |
360 |
42 |
|
Uttar Pradesh |
182 |
126 |
172 |
333 |
256 |
212 |
|
West Bengal |
658 |
377 |
379 |
398 |
66 |
-12 |
|
Private Sector |
1,523 |
2,057 |
1,042 |
2,276 |
2,813 |
1,643 |
|
All-India |
-54,683 |
-78,122 |
-59,189 |
-77,896 |
-13,766 |
-67,189 |
Note: Minus sign (-) indicates loss; Dadra & Nagar Haveli and Daman & Diu discom was privatised on April 1, 2022; New Delhi Municipal Council Distribution utility has been added from 2020-21 onwards.
Sources: Power Finance Corporation reports for various years; PRS.
